Development of Functional Beef Burgers with Pseudocereals and Study of their Physicochemical and Textural Properties

Bahmanyar, Fereshte; Hosseini, Seyede Marzieh; Mirmoghtadaie, Leila; Shojaee_Aliabadi, Saeedeh

doi:10.22101/JRIFST.2022.300264.1273

Development of Functional Beef Burgers with Pseudocereals and Study of their Physicochemical and Textural Properties

Document Type : Original Paper

Authors

Faculty of Nutrition Sciences and Food Technology, National Nutrition and Food Technology Research Institute, Shahid Beheshti University of Medical Sciences, Tehran, Iran

10.22101/JRIFST.2022.300264.1273

Abstract

The objective of this paper is to appraise the quinoa and buckwheat seeds as pseudocereals to develop new beef burgers. In this study, three different formulations were prepared: one control sample with 15% mixture of bread crumb with soy protein, and two samples with 15% quinoa flour (QB) and buckwheat flour (BB), respectively. This replacement did not make significant difference between the different formulations in most of the physicochemical characteristics including moisture content, pH value, frying properties and water activity but emulsion stability and protein content were higher in the control sample than new formulations. Based on the results of texture properties, raw control sample showed significantly harder texture but BB showed harder texture after frying. Moreover, raw quinoa burger had a higher lightness value (L*). A comparison between the QB and BB burger showed significantly increase in protein and fat content, emulsion stability and lightness of QB. In conclusion, the replacing of bread crumb and soy protein mixture by buckwheat and quinoa flours in beef burger, especially by quinoa flour did not cause significant damage to burger properties and might be a suitable strategy to produce a new functional burger with comparable physicochemical and textural properties.

Keywords

Main Subjects

Food Technology - Meat, Chicken, Fish and Their Products

This is an open-access article distributed under the terms and conditions of the Creative Commons Attribution 4.0 International (CC-BY 4.0). To view a copy of this license, visit (https://creativecommons.org/licenses/by/4.0/)

References

Abbasi Monjezi, M., Hosseini Shekarabi, S. P., & Hosseini, S. E. (2019). Study of Some Chemical Properties, Electrophoretic Pattern and Sensory Evaluation of Silver Carp Blend Burger with Vannamei Shrimp. Research and Innovation in Food Science and Technology, 8(3), 259-268. https://doi.org/10.22101/JRIFST.2019.09.17.835 ( in Persian)

Abdel-Naeem, H. H., & Mohamed, H. M. (2016). Improving the physico-chemical and sensory characteristics of camel meat burger patties using ginger extract and papain. Meat science, 118, 52-60. https://doi.org/10.1016/j.meatsci.2016.03.021

Alakali, J., Irtwange, S., & Mzer, M. (2010). Quality evaluation of beef patties formulated with bambara groundnut (Vigna subterranean L.) seed flour. Meat science, 85(2), 215-223. https://doi.org/10.1016/j.meatsci.2009.12.027

Ayadi, M., Kechaou, A., Makni, I., & Attia, H. (2009). Influence of carrageenan addition on turkey meat sausages properties. Journal of Food Engineering, 93(3), 278-283. https://doi.org/10.1016/j.jfoodeng.2009.01.033

Bahmanyar, F., Hosseini, S. M., Mirmoghtadaie, L., & Shojaee-Aliabadi, S. (2021). Effects of replacing soy protein and bread crumb with quinoa and buckwheat flour in functional beef burger formulation. Meat science, 172, 108305. https://doi.org/10.1016/j.meatsci.2020.108305

Basanta, M. F., Rizzo, S. A., Szerman, N., Vaudagna, S. R., Descalzo, A. M., Gerschenson, L. N., . . . Rojas, A. M. (2018). Plum (Prunus salicina) peel and pulp microparticles as natural antioxidant additives in breast chicken patties. Food Research International, 106, 1086-1094. https://doi.org/10.1016/j.foodres.2017.12.011

Cai, Y. Z., Corke, H., Wang, D., & Li, W. D. (2016). Buckwheat: Overview. In C. Wrigley, H. Corke, K. Seetharaman, & J. Faubion (Eds.), Encyclopedia of Food Grains (Second Edition) (pp. 307-315). Academic Press. https://doi.org/10.1016/B978-0-12-394437-5.00034-6

Carvalho, L. T., Pires, M. A., Baldin, J. C., Munekata, P. E. S., de Carvalho, F. A. L., Rodrigues, I., . . . Trindade, M. A. (2019). Partial replacement of meat and fat with hydrated wheat fiber in beef burgers decreases caloric value without reducing the feeling of satiety after consumption. Meat science, 147, 53-59. https://doi.org/10.1016/j.meatsci.2018.08.010

Choe, J.-H., Kim, H.-Y., Lee, J.-M., Kim, Y.-J., & Kim, C.-J. (2013). Quality of frankfurter-type sausages with added pig skin and wheat fiber mixture as fat replacers. Meat science, 93(4), 849-854. https://doi.org/10.1016/j.meatsci.2012.11.054

Choi, J.-H., Kim, N., Kim, G.-W., & Choi, H. Y. (2019). Effect of Cacao Nip Extracts (CEs) on Quality Characteristics of Pork Patties during Cold Storage Period. Food Science of Animal Resources, 39(6), 918-933. https://doi.org/10.5851/kosfa.2019.e77

Cuong, T. V., & Chin, K. B. (2016). Effects of Annatto (Bixa orellana L.) Seeds Powder on Physicochemical Properties, Antioxidant and Antimicrobial Activities of Pork Patties during Refrigerated Storage. Korean Journal for Food Science of Animal Resources, 36(4), 476-486. https://doi.org/10.5851/kosfa.2016.36.4.476

do Prado, M. E. A., Queiroz, V. A. V., Correia, V. T. d. V., Neves, E. O., Roncheti, E. F. S., Gonçalves, A. C. A., . . . de Oliveira, F. C. E. (2019). Physicochemical and sensorial characteristics of beef burgers with added tannin and tannin-free whole sorghum flours as isolated soy protein replacer. Meat science, 150, 93-100. https://doi.org/10.1016/j.meatsci.2018.12.006

Fernández‐Diez, A., Caro, I., Castro, A., Salvá, B. K., Ramos, D. D., & Mateo, J. (2016). Partial fat replacement by boiled quinoa on the quality characteristics of a dry‐cured sausage. Journal of food science, 81(8), C1891-C1898. https://doi.org/10.1111/1750-3841.13393

Heck, R. T., Vendruscolo, R. G., de Araújo Etchepare, M., Cichoski, A. J., de Menezes, C. R., Barin, J. S., . . . Campagnol, P. C. B. (2017). Is it possible to produce a low-fat burger with a healthy n− 6/n− 3 PUFA ratio without affecting the technological and sensory properties? Meat science, 130, 16-25. https://doi.org/10.1016/j.meatsci.2017.03.010

Horwitz, W., & Latimer, G. (2005). Official methods of analysis of AOAC international (18^th ed.). https://www.worldcat.org/title/official-methods-of-analysis-of-aoac-international/oclc/62751475

Hunt, M., Sørheim, O., & Slinde, E. (1999). Color and heat denaturation of myoglobin forms in ground beef. Journal of food science, 64(5), 847-851.

Li, G., & Zhu, F. (2017). Quinoa starch: Structures, properties, and applications. Carbohydrate polymers, 181, 851-861. https://doi.org/10.1016/j.carbpol.2017.11.067

López-Vargas, J. H., Fernández-López, J., Pérez-Álvarez, J. Á., & Viuda-Martos, M. (2014). Quality characteristics of pork burger added with albedo-fiber powder obtained from yellow passion fruit (Passiflora edulis var. flavicarpa) co-products. Meat science, 97(2), 270-276. https://doi.org/10.1016/j.meatsci.2014.02.010

Lorusso, A., Verni, M., Montemurro, M., Coda, R., Gobbetti, M., & Rizzello, C. G. (2017). Use of fermented quinoa flour for pasta making and evaluation of the technological and nutritional features. LWT - Food Science and Technology, 78, 215-221. https://doi.org/10.1016/j.lwt.2016.12.046

Öztürk-Kerimoğlu, B., Kavuşan, H. S., Tabak, D., & Serdaroğlu, M. (2020). Formulating Reduced-fat Sausages with Quinoa or Teff Flours: Effects on Emulsion Characteristics and Product Quality. Food Science of Animal Resources, 40(5), 710-721. https://doi.org/10.5851/kosfa.2020.e46

Park, S.-Y., Lee, J.-W., Kim, G.-W., & Kim, H.-Y. (2017). Effect of Black Rice Powder on the Quality Properties of Pork Patties. Korean Journal for Food Science of Animal Resources, 37(1), 71-78. https://doi.org/10.5851/kosfa.2017.37.1.71

Park, W., Kim, J.-H., Ju, M.-G., Yeon, S.-J., Hong, G.-E., & Lee, C.-H. (2016). Physicochemical and textural properties of pork patties as affected by buckwheat and fermented buckwheat. Journal of food science and technology, 53(1), 658-666. https://doi.org/10.1007/s13197-015-1973-2

Raúl, L. J., Araújo, I. B. d., Barbosa, R. C., Maciel, M. I. S., Shinohara, N. K. S., & Campagnoli de Oliveira Filho, P. R. (2018). Manufacture of Biquara (Haemulon Plumierii-Lacepède, 1801) Fishburger with Addition of Wheat Bran. Journal of aquatic food product technology, 27(5), 544-556. https://doi.org/10.1080/10498850.2018.1461159

Ruiz-Capillas, C., Triki, M., Herrero, A. M., Rodriguez-Salas, L., & Jiménez-Colmenero, F. (2012). Konjac gel as pork backfat replacer in dry fermented sausages: Processing and quality characteristics. Meat science, 92(2), 144-150. https://doi.org/10.1016/j.meatsci.2012.04.028

Salarkarimi, V., VARIDI, M., & Varidi, M. (2019). The Effect of Chestnut (Quercus Brantii) Flour Substitution on the Physicochemical and Sensory Properties of Burgers. Research and Innovation in Food Science and Technology, 8(1), 15-30. https://doi.org/10.22101/JRIFST.2019.04.30.812 (in Persian)

Sánchez-Zapata, E., Muñoz, C. M., Fuentes, E., Fernández-López, J., Sendra, E., Sayas, E., . . . Pérez-Alvarez, J. A. (2010). Effect of tiger nut fibre on quality characteristics of pork burger. Meat science, 85(1), 70-76. https://doi.org/10.1016/j.meatsci.2009.12.006

Senthil, A., Ravi, R., Bhat, K., & Seethalakshmi, M. (2002). Studies on the quality of fried snacks based on blends of wheat flour and soya flour. Food Quality and Preference, 13(5), 267-273. https://doi.org/10.1016/S0950-3293(02)00023-X

Serdaroğlu, M., Kavuşan, H. S., İpek, G., & Öztürk, B. (2018). Evaluation of the Quality of Beef Patties Formulated with Dried Pumpkin Pulp and Seed. Korean Journal for Food Science of Animal Resources, 38(1), 1-13. https://doi.org/10.5851/kosfa.2018.38.1.001

Sharma, P., & Yadav, S. (2020). Effect of Incorporation of Pomegranate Peel and Bagasse Powder and Their Extracts on Quality Characteristics of Chicken Meat Patties. Food Science of Animal Resources, 40(3), 388-400. https://doi.org/10.5851/kosfa.2020.e19

Soltanizadeh, N., & Ghiasi-Esfahani, H. (2015). Qualitative improvement of low meat beef burger using Aloe vera. Meat science, 99, 75-80. https://doi.org/10.1016/j.meatsci.2014.09.002

Tamsen, M., Shekarchizadeh, H., & Soltanizadeh, N. (2018). Evaluation of wheat flour substitution with amaranth flour on chicken nugget properties. LWT, 91, 580-587. https://doi.org/10.1016/j.lwt.2018.02.001

Valencia, D. G., Serrano, M. P., Jiménez-Moreno, E., Lázaro, R., & Mateos, G. G. (2009). Ileal digestibility of amino acids of pea protein concentrate and soya protein sources in broiler chicks. Livestock Science, 121(1), 21-27. https://doi.org/10.1016/j.livsci.2008.05.013

Vega‐Gálvez, A., Miranda, M., Vergara, J., Uribe, E., Puente, L., & Martínez, E. A. (2010). Nutrition facts and functional potential of quinoa (Chenopodium quinoa willd.), an ancient Andean grain: a review. Journal of the Science of Food and Agriculture, 90(15), 2541-2547. https://doi.org/0.1002/jsfa.4158

Zahid, M. A., Seo, J.-k., Parvin, R., Ko, J., Park, J.-Y., & Yang, H.-S. (2020). Assessment of the Stability of Fresh Beef Patties with the Addition of Clove Extract during Frozen Storage. Food Science of Animal Resources, 40(4), 601-612. https://doi.org/10.5851/kosfa.2020.e37