Research and Innovation in Food Science and Technology

The Effect of Ultrasound Pretreatment on Hydrolysis Time of Edible Mushroom (Agaricus bisporus) Proteins by Pancreatin to Produce of Antioxidant Peptides

Document Type : Original Paper

Authors

Department of Food Science and Technology, Gorgan University of Agricultural Sciences and Natural Resources, Gorgan, Iran

Abstract

Due to the length of the time required for protein hydrolysis, ultrasound, as a cheap technology, can be used as a pre-treatment in protein hydrolysis to shorten the time. The aim of this study was to investigate the effect of hydrolysis time and ultrasonic pretreatment on enzymatic hydrolysis of edible mushroom proteins by pancreatin enzyme to produce short chain peptides with high antioxidant capacity. In this research first edible mushrooms were turned into powder then hydrolysed during 30-210 min with enzyme to substrate ratio of 1% and at temperature of 40 °C without pretreatment, and with pretreatment by 80 and 40% ultrasound power. Increasing the power of ultrasonic treatment increased the 2,2-diphenyl-1-picrylhydrazyl (DPPH) free radical scavenging activity and total antioxidant capacity at shorter hydrolysis time. The highest DPPH free radical scavenging activity in untreated and treated samples with 40 and 80% ultrasound power were 39.96, 42.91 and 47.76, respectively. The highest total antioxidant capacity for untreated and treated samples with 40 and 80% ultrasound power was 1.64, 1.73 and 1.98 (absorption at 695 nm), respectively. The results showed that the highest reducing power of Fe3+ in untreated and treated samples with 40 and 80% ultrasound power were 2.61, 2.84 and 2.90 (absorption at 700 nm), respectively. These results showed that pre-treated samples with 80% ultrasound compared to samples without pretreatment and pre-treated with 40% ultrasound had the highest antioxidant properties. Therefore, the use of high power ultrasonic pretreatment shortens the hydrolysis time to achieve peptides with higher antioxidant capacity.

Keywords

Main Subjects

© 2023, Research Institute of Food Science and Technology. All rights reserved.

This is an open-access article distributed under the terms and conditions of the Creative Commons Attribution 4.0 International (CC-BY 4.0). To view a copy of this license, visit (https://creativecommons.org/licenses/by/4.0/).

Aderinola, T. A., Fagbemi, T. N., Enujiugha, V. N., Alashi, A. M., & Aluko, R. E. (2019). In vitro antihypertensive and antioxidative properties of alcalase-derived Moringa oleifera seed globulin hydrolysate and its membrane fractions. Journal of Food Processing and Preservation, 43(2), e13862. https://doi.org/10.1111/jfpp.13862
AOAC. (1970). Official methods of analysis of the Association of Official Analytical Chemists. https://search.library.wisc.edu/catalog/999488096402121
Arabshahi-Delouee, S., & Urooj, A. (2007). Antioxidant properties of various solvent extracts of mulberry (Morus indica L.) leaves. Food Chemistry, 102(4), 1233-1240. https://doi.org/10.1016/j.foodchem.2006.07.013
Bougatef, A., Hajji, M., Balti, R., Lassoued, I., Triki-Ellouz, Y., & Nasri, M. (2009). Antioxidant and free radical-scavenging activities of smooth hound (Mustelus mustelus) muscle protein hydrolysates obtained by gastrointestinal proteases. Food Chemistry, 114(4), 1198-1205. https://doi.org/10.1016/j.foodchem.2008.10.075
Chandrapala, J., Oliver, C., Kentish, S., & Ashokkumar, M. (2012). Ultrasonics in food processing – Food quality assurance and food safety. Trends in Food Science & Technology, 26(2), 88-98. https://doi.org/10.1016/j.tifs.2012.01.010
Chen, L., Chen, J., Ren, J., & Zhao, M. (2011). Effects of ultrasound pretreatment on the enzymatic hydrolysis of soy protein isolates and on the emulsifying properties of hydrolysates. J Agric Food Chem, 59(6), 2600-2609. https://doi.org/10.1021/jf103771x
Chi, C.-F., Hu, F.-Y., Wang, B., Li, T., & Ding, G.-F. (2015). Antioxidant and anticancer peptides from the protein hydrolysate of blood clam (Tegillarca granosa) muscle. Journal of Functional Foods, 15, 301-313. https://doi.org/10.1016/j.jff.2015.03.045
Ding, Q., Zhang, T., Niu, S., Cao, F., Wu-Chen, R. A., Luo, L., & Ma, H. (2018). Impact of ultrasound pretreatment on hydrolysate and digestion products of grape seed protein. Ultrasonics Sonochemistry, 42, 704-713. https://doi.org/10.1016/j.ultsonch.2017.11.027
Fiaschi, T., & Chiarugi, P. (2012). Oxidative stress, tumor microenvironment, and metabolic reprogramming: a diabolic liaison. Int J Cell Biol, 2012, 762825. https://doi.org/10.1155/2012/762825
FitzGerald, R. J., & Meisel, H. (2000). Milk protein-derived peptide inhibitors of angiotensin-I-converting enzyme. Br J Nutr, 84 Suppl 1, S33-37. https://doi.org/10.1017/s0007114500002221
Guerra-Almonacid, C. M., Torruco-Uco, J. G., Jonh Jairo Méndez-Arteaga, W. M.-A., & Rodríguez-Miranda, J. (2019). Effect of ultrasound pretreatment on the antioxidant capacity and antihypertensive activity of bioactive peptides obtained from the protein hydrolysates of Erythrina edulis. Emirates Journal of Food and Agriculture, 31(4), 288-296. https://doi.org/10.9755/ejfa.2019.v31.i4.1938
He, J. Z., Ru, Q. M., Dong, D. D., & Sun, P. L. (2012). Chemical characteristics and antioxidant properties of crude water soluble polysaccharides from four common edible mushrooms. Molecules, 17(4), 4373-4387. https://doi.org/10.3390/molecules17044373
Jamdar, S. N., Rajalakshmi, V., Pednekar, M. D., Juan, F., Yardi, V., & Sharma, A. (2010). Influence of degree of hydrolysis on functional properties, antioxidant activity and ACE inhibitory activity of peanut protein hydrolysate. Food Chemistry, 121(1), 178-184. https://doi.org/10.1016/j.foodchem.2009.12.027
Janakat, S., Al-Fakhiri, S., & Sallal, A. K. (2004). A promising peptide antibiotic from Terfezia claveryi aqueous extract against Staphylococcus aureus in vitro. Phytother Res, 18(10), 810-813. https://doi.org/10.1002/ptr.1563
Je, J.-Y., Lee, K.-H., Lee, M. H., & Ahn, C.-B. (2009). Antioxidant and antihypertensive protein hydrolysates produced from tuna liver by enzymatic hydrolysis. Food Research International, 42(9), 1266-1272. https://doi.org/10.1016/j.foodres.2009.06.013
Jia, J., Ma, H., Zhao, W., Wang, Z., Tian, W., Luo, L., & He, R. (2010). The use of ultrasound for enzymatic preparation of ACE-inhibitory peptides from wheat germ protein. Food Chemistry, 119(1), 336-342. https://doi.org/10.1016/j.foodchem.2009.06.036
Kadam, S. U., Tiwari, B. K., Álvarez, C., & O'Donnell, C. P. (2015). Ultrasound applications for the extraction, identification and delivery of food proteins and bioactive peptides. Trends in Food Science & Technology, 46(1), 60-67. https://doi.org/10.1016/j.tifs.2015.07.012
Lavi, I., Nimri, L., Levinson, D., Peri, I., Hadar, Y., & Schwartz, B. (2012). Glucans from the edible mushroom Pleurotus pulmonarius inhibit colitis-associated colon carcinogenesis in mice. J Gastroenterol, 47(5), 504-518. https://doi.org/10.1007/s00535-011-0514-7
Li, X., Da, S., Li, C., Xue, F., & Zang, T. (2018). Effects of high-intensity ultrasound pretreatment with different levels of power output on the antioxidant properties of alcalase hydrolyzates from Quinoa (Chenopodium quinoa Willd.) protein isolate. Cereal Chemistry, 95(4), 518-526. https://doi.org/10.1002/cche.10055
Li, X. R., Chi, C. F., Li, L., & Wang, B. (2017). Purification and Identification of Antioxidant Peptides from Protein Hydrolysate of Scalloped Hammerhead (Sphyrna lewini) Cartilage. Mar Drugs, 15(3). https://doi.org/10.3390/md15030061
Liang, Q., Ren, X., Ma, H., Li, S., Xu, K., & Oladejo, A. O. (2017). Effect of Low-Frequency Ultrasonic-Assisted Enzymolysis on the Physicochemical and Antioxidant Properties of Corn Protein Hydrolysates. Journal of Food Quality, 2017, 2784146. https://doi.org/10.1155/2017/2784146
Matmaroh, K., Benjakul, S., Prodpran, T., Encarnacion, A. B., & Kishimura, H. (2011). Characteristics of acid soluble collagen and pepsin soluble collagen from scale of spotted golden goatfish (Parupeneus heptacanthus). Food Chemistry, 129(3), 1179-1186. https://doi.org/10.1016/j.foodchem.2011.05.099
Meshginfar, N., Sadeghi, M. A., Ziaiifar, A. M., Ghorbani, M., & Kashaninejad, M. (2014). Optimization of the production of protein hydrolysates from meat industry by products by response surface methodology. Journal of Food Research, 24(2), 215-225. https://foodresearch.tabrizu.ac.ir/article_1815_58050bcdf8482dba877ad2986115e9b3.pdf
Mine, Y., Li-Chan, E., & Jiang, B. (2010). Bioactive proteins and peptides as functional foods and nutraceuticals (Vol. 29). John Wiley & Sons.
Nadeem, M., Ubaid, N., Qureshi, T. M., Munir, M., & Mehmood, A. (2018). Effect of ultrasound and chemical treatment on total phenol, flavonoids and antioxidant properties on carrot-grape juice blend during storage. Ultrasonics Sonochemistry, 45, 1-6. https://doi.org/10.1016/j.ultsonch.2018.02.034
Oboh, G., & Shodehinde, S. (2009). Distribution of nutrients, polyphenols and antioxidant activities in the pilei and stipes of some commonly consumed edible mushrooms in Nigeria. Bulletin of the Chemical Society of Ethiopia, 23(3).
Paisansak, S., Sangtanoo, P., Srimongkol, P., Saisavoey, T., Reamtong, O., Choowongkomon, K., & Karnchanatat, A. (2021). Angiotensin-I converting enzyme inhibitory peptide derived from the shiitake mushroom (Lentinula edodes). J Food Sci Technol, 58(1), 85-97. https://doi.org/10.1007/s13197-020-04517-z
Pan, A. D., Zeng, H. Y., Alain, G. B., & Feng, B. (2016). Heat-pretreatment and enzymolysis behavior of the lotus seed protein. Food Chem, 201, 230-236. https://doi.org/10.1016/j.foodchem.2016.01.069
Pan, X., Zhao, Y.-Q., Hu, F.-Y., & Wang, B. (2016). Preparation and identification of antioxidant peptides from protein hydrolysate of skate (Raja porosa) cartilage. Journal of Functional Foods, 25, 220-230. https://doi.org/10.1016/j.jff.2016.06.008
Parhizkari, K., Hosseini, E., & Sharifi, A. (2019). Investigation of Properties of Bioactive Peptides Derived from Enzymatic Hydrolysis of Chicken Slaughter Waste. Iranian Journal of Biosystems Engineering, 49(4), 589-596. https://doi.org/10.22059/ijbse.2018.243764.664999
Piri, S., sadeghimahoonak, a., ghorbani, m., & Alami, M. (2015). Production and study on antioxidant activity of protein hydrolysate from whey protein. Research and Innovation in Food Science and Technology, 4(3), 271-282. https://doi.org/10.22101/jrifst.2015.11.22.437
Prieto, P., Pineda, M., & Aguilar, M. (1999). Spectrophotometric Quantitation of Antioxidant Capacity through the Formation of a Phosphomolybdenum Complex: Specific Application to the Determination of Vitamin E. Analytical Biochemistry, 269(2), 337-341. https://doi.org/10.1006/abio.1999.4019
Qu, W., Ma, H., Liu, B., He, R., Pan, Z., & Abano, E. E. (2013). Enzymolysis reaction kinetics and thermodynamics of defatted wheat germ protein with ultrasonic pretreatment. Ultrasonics Sonochemistry, 20(6), 1408-1413. https://doi.org/10.1016/j.ultsonch.2013.04.012
Ren, X., Ma, H., Mao, S., & Zhou, H. (2014). Effects of sweeping frequency ultrasound treatment on enzymatic preparations of ACE-inhibitory peptides from zein. European Food Research and Technology, 238(3), 435-442. https://doi.org/10.1007/s00217-013-2118-3
Téllez-Morales, J. A., Hernández-Santo, B., & Rodríguez-Miranda, J. (2020). Effect of ultrasound on the techno-functional properties of food components/ingredients: A review. Ultrasonics Sonochemistry, 61, 104787. https://doi.org/10.1016/j.ultsonch.2019.104787
Wali, A., Ma, H., Shahnawaz, M., Hayat, K., Xiaong, J., & Jing, L. (2017). Impact of Power Ultrasound on Antihypertensive Activity, Functional Properties, and Thermal Stability of Rapeseed Protein Hydrolysates. Journal of Chemistry, 2017, 4373859. https://doi.org/10.1155/2017/4373859
Walters, M. E. (2019). Effects of Ultrasonication on the Antioxidant and Anti-diabetic Properties of Hydrolyzed Oat Proteins  [Thesis]. Carleton University. https:/repository.library.carleton.ca/files/cr56n209d
Wang, B., Atungulu, G. G., Khir, R., Geng, J., Ma, H., Li, Y., & Wu, B. (2015). Ultrasonic Treatment Effect on Enzymolysis Kinetics and Activities of ACE-Inhibitory Peptides from Oat-Isolated Protein. Food Biophysics, 10(3), 244-252. https://doi.org/10.1007/s11483-014-9375-y
Wang, B., Meng, T., Ma, H., Zhang, Y., Li, Y., Jin, J., & Ye, X. (2016). Mechanism study of dual-frequency ultrasound assisted enzymolysis on rapeseed protein by immobilized Alcalase. Ultrasonics Sonochemistry, 32, 307-313. https://doi.org/10.1016/j.ultsonch.2016.03.023
Wang, Z., Liu, X., Xie, H., Liu, Z., Rakariyatham, K., Yu, C., . . . Zhou, D. (2021). Antioxidant activity and functional properties of Alcalase-hydrolyzed scallop protein hydrolysate and its role in the inhibition of cytotoxicity in vitro. Food Chemistry, 344, 128566. https://doi.org/10.1016/j.foodchem.2020.128566
Wen, C., Zhang, J., Zhang, H., Dzah, C. S., Zandile, M., Duan, Y., . . . Luo, X. (2018). Advances in ultrasound assisted extraction of bioactive compounds from cash crops – A review. Ultrasonics Sonochemistry, 48, 538-549. https://doi.org/10.1016/j.ultsonch.2018.07.018
Yang, X., Li, Y., Li, S., Oladejo, A. O., Wang, Y., Huang, S., . . . Ye, X. (2017). Effects of multi-frequency ultrasound pretreatment under low power density on the enzymolysis and the structure characterization of defatted wheat germ protein. Ultrasonics Sonochemistry, 38, 410-420. https://doi.org/10.1016/j.ultsonch.2017.03.001
Yildirim, A., Mavi, A., Oktay, M., Kara, A. A., Algur, O. F., & Bilaloglu, V. (2000). Comparison of antioxidant and antimicrobial activities of tilia (Tilia argentea Desf ex DC), sage (Salvia triloba l.), and black tea (Camellia sinensis) extracts. J Agric Food Chem, 48(10), 5030-5034. https://doi.org/10.1021/jf000590k
You, L., Zhao, M., Cui, C., Zhao, H., & Yang, B. (2009). Effect of degree of hydrolysis on the antioxidant activity of loach (Misgurnus anguillicaudatus) protein hydrolysates. Innovative Food Science & Emerging Technologies, 10(2), 235-240. https://doi.org/10.1016/j.ifset.2008.08.007
Yu, L., Sun, J., Liu, S., Bi, J., Zhang, C., & Yang, Q. (2012). Ultrasonic-assisted enzymolysis to improve the antioxidant activities of peanut (Arachin conarachin L.) antioxidant hydrolysate. Int J Mol Sci, 13(7), 9051-9068. https://doi.org/10.3390/ijms13079051
Zhang, Y., Ma, L., Cai, L., Liu, Y., & Li, J. (2017). Effect of combined ultrasonic and alkali pretreatment on enzymatic preparation of angiotensin converting enzyme (ACE) inhibitory peptides from native collagenous materials. Ultrasonics Sonochemistry, 36, 88-94. https://doi.org/10.1016/j.ultsonch.2016.11.008
Zhou, C., Hu, J., Yu, X., Yagoub, A. E. A., Zhang, Y., Ma, H., . . . Otu, P. N. Y. (2017). Heat and/or ultrasound pretreatments motivated enzymolysis of corn gluten meal: Hydrolysis kinetics and protein structure. LWT, 77, 488-496. https://doi.org/10.1016/j.lwt.2016.06.048
Zhu, K.-X., Su, C.-Y., Guo, X.-N., Peng, W., & Zhou, H.-M. (2011). Influence of ultrasound during wheat gluten hydrolysis on the antioxidant activities of the resulting hydrolysate. International Journal of Food Science & Technology, 46(5), 1053-1059. https://doi.org/10.1111/j.1365-2621.2011.02585.x
Zhu, L., Chen, J., Tang, X., & Xiong, Y. L. (2008). Reducing, Radical Scavenging, and Chelation Properties of in Vitro Digests of Alcalase-Treated Zein Hydrolysate. Journal of Agricultural and Food Chemistry, 56(8), 2714-2721. https://doi.org/10.1021/jf703697e
Zou, Y., Wang, W., Li, Q., Chen, Y., Zheng, D., Zou, Y., . . . Yang, L. (2016). Physicochemical, functional properties and antioxidant activities of porcine cerebral hydrolysate peptides produced by ultrasound processing. Process Biochemistry, 51(3), 431-443. https://doi.org/10.1016/j.procbio.2015.12.011
Zou, Y., Yang, H., Li, P. P., Zhang, M. H., Zhang, X. X., Xu, W. M., & Wang, D. Y. (2019). Effect of different time of ultrasound treatment on physicochemical, thermal, and antioxidant properties of chicken plasma protein. Poultry Science, 98(4), 1925-1933. https://doi.org/10.3382/ps/pey502
Send comment about this article
CAPTCHA Image
Research and Innovation in Food Science and Technology
Volume 12, Issue 2
September 2023
Pages 191-204
  • Receive Date: 11 June 2022
  • Revise Date: 12 January 2023
  • Accept Date: 21 January 2023