The Investigation of Sage Seed and Persian Gum Coating Effect on Oil Mass Transfer and Quality Attributes of Potato Chips

Naji Tabasi, Sima; Mahdian, Elham

doi:10.22101/JRIFST.2017.09.02.625

The Investigation of Sage Seed and Persian Gum Coating Effect on Oil Mass Transfer and Quality Attributes of Potato Chips

Document Type : Original Paper

Authors

Sima Naji Tabasi ¹
Elham Mahdian ²

¹ Ph.D student, Department of Food Science and Technology, Quchan Branch, Islamic Azad University, Quchan, Iran

² Assistant Professor, Department of Food Science and Technology, Quchan Branch, Islamic Azad University, Quchan, Iran

10.22101/JRIFST.2017.09.02.625

Abstract

Growing consumption of fried foods can cause various diseases; therefore it is important to create an appropriate method to reduce oil absorption uptake in these products. In this study, the effects of sage seed gum and Persian gum coating (0.25 and 0.5% w/w) by immersion and spraying methods on fried potato chips properties (coating rate, oil absorption, oil fractions, color, texture and sensory properties) in deep frying were studied. Both methods reduced oil uptake significantly. However, oil effective penetration was different depending on the coating. The highest coating rate (3.6%) and the least oil absorption (31.24 percent) with 0.27 ± 0.001 1/s absorption rate was contributed to sage seed sample at 0.5% (w/w) concentration by immersion method, whose difference was significant in the control sample (37.21%) (P<0.05). According to texture analysis results, chips stiffness increased significantly by immersion method. Although, the most desirable texture was contributed to coated samples by immersion method according to sensory evaluation results. There was no significant difference between coated samples and control in smell, appearance, taste and overall acceptance (P>0.05). As a result, sage seed gum at 0.5% concentration and immersion coating method with the lowest oil absorption and similar organoleptic properties to the witness is recommended to be used in potato chips production.

Keywords

References

امیریوسفی، م.ر. 1389. بررسی کنتیک انتقال جرم، خصوصیات فیزیکوشیمیایی و بعد بر خالی فیلۀ گوشت شترمرغ سرخ‌شده به‌ روش عمیق با استفاده از شبکه‌های عصبی مصنوعی. پایان‌نامۀ کارشناسی ارشد، دانشگاه فردوسی مشهد.

بستان، الف. 1387. بهینه‌یابی شرایط استخراج عصارۀ خام هیدروکلوئیدی دانۀ مرو و بررسی خواص رئولوژیکی مستقل از زمان آن. پایان‌نامۀ کارشناسی ارشد، دانشگاه فردوسی مشهد.

خالصی، ه.، کدخدایی، ر. و عمادزاده، ب. 1395. بررسی اثر صمغ فارسی و فرایند حرارتی بر ویژگی‌های امولسیون پایدارشده با کنسانترۀ پروتئین آب‌پنیر. فصلنامه فناوری‌های نوین غذایی، 4(13): 119-103.

زمانی، ع. 1389. ارزیابی اثر صمغ‌های دانه ریحان، متیل سلولز و گزانتان بر میزان جذب روغن خلال‌های سیب‌زمینی طی سرخ‌کردن عمیق. پایان‌نامۀ کارشناسی ارشد، دانشگاه فردوسی مشهد.

شرایعی، پ. 1389 . اثر روغن مغز پستۀ وحشی، مواد صابونی‌ناشوندۀ آن بر پایداری مخلوط کانولا/پالم ‌اولئین/زیتون و نوع روغن و فرایندهای مقدماتی بر میزان جذب روغن سیب‌زمینی طی فرایند سرخ‌کردن عمیق. پایان‌نامۀ دکتری، دانشگاه فردوسی مشهد.

گرمه‌خانی، الف.، میرزایی، ح.، مقصودلو، ی. و کاشانی‌نژاد، م. 1388. تأثیر مواد هیدروکلوئیدی بر جذب روغن و خواص کیفی خلال نیمه‌سرخ‌شدۀ سیب‌زمینی. مجله علوم کشاورزی و منابع طبیعی، 16(3): 123-135.

گرمه‌خانی، الف.، میرزایی، ح.، کاشانی‌نژاد، م. و مقصودلو، ی. 1387. استفاده از مواد هیدروکلوئیدی به‌عنوان پوشش‌های خوراکی به‌منظور تولید چیپس کم‌چرب. مجله علوم کشاورزی و منابع طبیعی، 15(6): 170-175.

AACC. 1986. Moisture content. In approved methods of the American Association of Chemists. St aul, MN: AACC.

Adedeji, A.A., Ndsgi, M.O., & Raghavan, G.S.V. 2009. Kinetics of mass transfer in microwave precooked and deep fat fried chicken nuggets. Journal of Food Engineering, 91(1): 146-153.

Akdeniz, N., Sahin, S., & Sumnu, G. 2006. Functionality of batters containing different gums for deep fat frying of carrot slices. Journal of Food Engineering, 75(4): 522-526.

Akdeniz, N. 2004. Effects of different batter formulations on quality of deep-fat fried carrot slices. A Thesis Submitted to the Graduate school of Nartural and Applied Sciences of Middle east Technical University.

AOAC. 2005. Official Methods of Analysis. Association of Official Analytical Chemists. Washington. DC.

Blumenthal, M.M. 1991. A new look at the chemistry and physics of deep-fat frying. Food Technology, 45: 65-94.

Bostan, A., Razavi, S.M., & Farhoosh, R. 2010. Optimization of hydrocolloid extraction from wild sage seed (Salvia macrosiphon) using response surface. International Journal of Food Properties 13(6):1380-1392.

Bouchon, P., Aguilera, J.M., & Pyle, D.L. 2003. Structure oilabsorption relationships during deep-fat frying. Journal of Food Science, 68(9): 2711-2716.

Debnath, S., Bhat, K.K., & Rastogi, S. 2003. Effect of pre-drying on kinetics of moisture loss and oil uptake during deep fat frying of chickpea flour-based snack food. Lebensmittel-Wissenschaft und- Technology, 36(1): 91-98.

Dobarganes, C., Marquez-Ruiz, G., & Velasco, J. 2000. Interactions between fat and food during deep-frying. European Journal of Lipid Science and Technology, 102(8‐9):521-528.

Duran, M., Pedreschi, F., Moyano, P., & Troncoso, E. 2007.in Oil partition przetreated potato slices during frying and cooling. Journal of Food Engineering, 81(1):257-265.

Garcia, M.A., Ferrero, C., Bertola, N., Martino, M., & Zaritzky, N. 2002. Methylcellulose coatings applied to reduce oil uptake in fried products. Food Science and Technology International, 10(5): 339-346.

Khalil, A.H. 1999. Quality of french fried potatoes as inuenced by coating with hydrocolloids. Food Chemistry, 66(92): 201-208.

Krokida, M.K., Oreopoulou, V., Maroulis, Z.B., & Marinos-Kouris, D. 2001b. Effect of Osmotic Dehydration Pretreatment on Quality of French Fries. Journal of Food Engineering, 49(4):339-345.

Mallikarjunan, P., Chinnan, M.S., Balasubramaniam, V.M., & Phillips, R.D. 1997.Edible coatings for deep-fat frying of starchy products. Lebensmittel-Wissenschaft und-Technologie, 30(7):709-714.

Mellema, M. 2003. Mechanisms and reduction of fat uptake in deep fat fried foods. Trends in Food Scieence and Technology, 14(9):364-373.

Moreira, R.G., Da Silva, P.F., & Gomes, C. 2009. The effect of a de-oiling mechanism on the production of high quality vacuum fried potato chips. Journal of Food Engineering, 92(3):297-304.

Moyano, P.C., & Pedreschi, F. 2006. Kinetics of oil uptake during frying of potato slices: Effect of pre-treatments. LWT-Food Science and Technology, 39(3):285-291.

Pineda, M.D.L.T. 2007. Fortification of baked and fried tortilla chips with mechanically expelled soy flour (Doctoral dissertation, Texas A&M University).‏

Rimac-Brncic, S., Lelas, V., Rade, D., & Simundic, B. 2004. Decreasing of oil absorption in potato strips during deep fat frying. Journal of Food Engineering, 64(2): 237-241.

Sahin, S., & Sumnu, G.S. 2009. Avances in Deep Fat Frying of Foods, CRC Press, USA.

Susanne, A., & Gauri, S.M. 2002. Comparative evaluation of edible coatings to reduce fat uptake in a deep-fried cereal product. Journal of Food Research International, 35(5): 445-458.

Williams, P.A., & Philips, G.O. 2000. Introduction to food hydrocolloids. In:Handbook of Hydrocolloids, Edited by Phillips, G.O. & Williams, P.A., pp. 22-40, Woodhead Publishing Limited: Cambridge, UK.

Williams, R., & Mittal, G.S. 1999. Low fat fried foods with edible coatings: modeling and simulation. Journal of Food Science, 64(2): 317-322.

Yagua, C.V., & Moreira, R.G. 2011. Physical and thermal properties of potato chips during vacuum frying. Journal of Food Engineering, 104(2): 272-283.